Microwave – Assisted Extraction of Chlorogenic Acid from Coffee liberica L

https://doi.org/10.22146/ajche.49709

Josephine Q. Borja(1*), Marylou M Uy(2), Jose Salvador Lim(3), Matthew Edson Ong(4), Alejandro Miguel Ros(5)

(1) Chemical Engineering Department, Gokongwei College of Engineering, De La Salle University, 2401 Taft Avenue, Manila
(2) Chemical Engineering Department, Gokongwei College of Engineering, De La Salle University, 2401 Taft Avenue, Manila
(3) Chemical Engineering Department, Gokongwei College of Engineering, De La Salle University, 2401 Taft Avenue, Manila
(4) Chemical Engineering Department, Gokongwei College of Engineering, De La Salle University, 2401 Taft Avenue, Manila
(5) Chemical Engineering Department, Gokongwei College of Engineering, De La Salle University, 2401 Taft Avenue, Manila
(*) Corresponding Author

Abstract


This study applied microwave-assisted extraction of chlorogenic acid (CGA) from Coffee liberica L. using ethanol as solvent. It sought to determine the effects of temperature, extraction time, solvent-to-solid ratio, and solvent concentration on the CGA yield expressed as gallic acid equivalent per litre (mg GAE L-1). The values of these factors were varied at three levels each and experiments were implemented using the L934 orthogonal array of the Taguchi design of experiment. Results showed that increasing the solvent-to-solid ratio from 2.5 to 7.5 mL g--1decreased the yield significantly. Conversely, increasing the solvent concentration from 0.6 to 0.7 (v v-1) increased the yield, but beyond this, lower yield was obtained. Likewise, yield increased when the extraction time was increased from 5 to 7 minutes but decreased subsequently when extraction was extended to 10 minutes. Temperature did not show significant effect on yield. Among the factors tested the solvent- to-solid ratio has the most significant effect on yield, followed by solvent concentration and extraction time while temperature had no significant effect. In the Taguchi design the highest yield of 304.90±0.58 mg GAE L-1 was obtained at 90°C, extraction time of 7 minutes, solvent-to-solid ratio of 2.5 mL g-1 and solvent concentration of 0.8 (v v-1). Using the same extraction temperature and time and solvent-to-solid ratio but lower solvent concentration, the confirmatory run resulted is significantly higher yield of 854.35±3.35 mg GAE L-1. Chlorogenic acid was identified in the extract at a concentration of 3152 mg L-1. By applying Soxhlet extraction using the same solvent concentration and solvent-to-solid ratio at the same temperature as that of the confirmatory run the yield was significantly lower at 570.42±5.3 mg GAE L-1.

Keywords


Polyphenols; chlorogenic acid, antioxidant, microwave-assisted extraction; Taguchi method

Full Text:

PDF


References

  1. Brezová, V., Šlebedová, A. and Stásko A. (2008). Coffee as a Source of Antioxidants: an EPR study, Food Chem., 114(3), 859-868.
  2. Gamse T. (2002). Liquid-Liquid and Solid-Liquid Extraction. Institute of Thermal Process and Environmental Engineering, Graz University of Technology.
  3. Hu, F., Deng, C., Liu, Y. and X. Zhang. (2009). Quantitative Determination of Chlorogenic Acid in Honeysuckle Using Microwave-Assisted Extraction Followed by Nano-LC-ESI Mass Spectrometry. Talanta, 77(4), 1299–1303.
  4. Huie, C. W. (2002). A Review of Modern Sample Preparation Techniques for the Extraction and Analysis of Medicinal Plants. Anal. Bioanal. Chem., 373(1-2), 23-30.
  5. Katsube, T., Tsurunaga, Y., Sugiyama, M., Furuno, T. and Y. Yamasaki. (2009) Effect of Air-Drying Temperature on Antioxidant Capacity and Stability of Polyphenolic Compounds in Mulberry (Morus alba L.) Leaves, Food Chem., 113(4), 964-969.
  6. Kojić-Bucić, A., Planinić, M., Tomas, S., Bilić, M. and Velić, D. (2007). Study of Solid–Liquid Extraction Kinetics of Total Polyphenols from Grape Seeds, J. Food Eng., 81(1), 236-242.
  7. Manach, C., Scalbert, A., Morand, C., Rémésy, C. and Jime ́nez, L. (2004). Polyphenols: Food Sources and Bioavailability, Am. J. of Clin. Nutr., 79(5), 727-747.
  8. Mandal, V., Mohan, Y. and S. Hemalatha. (2007). Microwave-Assisted Extraction – An Innovative and Promising Extraction Tool for Medicinal Plant Research. Phcog. Rev., 1(1), 7-1.
  9. Mendonca, J. C., Franca, A. S., Oliveira, L. S. and Nunes, M. (2008). Analytical Methods: Chemical Characterization of Non-defective and Defective Green Arabica and Robusta Coffees by Electrospray Ionization-mass Spectrometry, Food Chem., 111(2), 490-497.
  10. Naidu, M. M., Sulochanamma, G., Sampathu, S. R. and Srinivas. P. (2008). Studies on Extraction and Antioxidant Potential of Green Coffee, Food Chem., 107(1), 377–384.
  11. Pan, X., Guoguang, N. and Huizhou, L. (2003). Microwave-Assisted Extraction of Tea Polyphenols and Tea Caffeine from Green Tea Leaves, Chem. Eng. Process., 42(2), 129-133.
  12. Pérez-Seradilla, J. A., Japón-Luján, R. and de Castro, M. D. (2007). Simultaneous Microwave-Assisted Solid-Liquid Extraction of Polar and Non-polar Compounds from Alperujo. Anal. Chim. Acta., 602(1), 82-88.
  13. Priego-Capote, F., Ruiz-Jimenez, J., de Castro M. D. (2004). Fast Separation and Determination of Phenolic Compounds by Capillary Electrophoresis-diode Array Detection: Application to the Characterization of Alperujo After Ultrasound-Assisted Extraction. J. Chromatogr A., 1045(1- 2), 239-246.
  14. Sacchetti, G., Di Mattia, C., Pittia, P. and Mastracola, D. (2009). Effect of Roasting Degree, Equivalent Thermal Effect and Coffee Type on Radical Scavenging Activity of Coffee Brews and their Phenolic Fraction J Food Eng., 90(1), 74- 80.
  15. Wang, Z., Wang, L., Li, T., Zhon, X., Ding, L., Yu, Y., Yu , A. and H. Zhang. (2006). Rapid Analysis of the Essential Oils from Dried Illicum verum Hook. and Zingiber officinale. Rosc. by Improved Solvent Free Extraction Microwave with Three Types of Microwave Absorption Medium. Anal. Bioanal. Chem., 386(6), 1863-1868.
  16. Wang, L. and Weller, C. L. (2006). Recent Advances in Extraction of Neutraceuticals from Plants. Trends in Food Sci Tech.,17, 300-312
  17. Zhou, H. and Liu, C. (2006). Microwave assisted extraction of solanesol from tobacco leaves. J. Chromatogr. A. 1129, 135-39.



DOI: https://doi.org/10.22146/ajche.49709

Article Metrics

Abstract views : 1942 | views : 2189

Refbacks

  • There are currently no refbacks.


ASEAN Journal of Chemical Engineering  (print ISSN 1655-4418; online ISSN 2655-5409) is published by Chemical Engineering Department, Faculty of Engineering, Universitas Gadjah Mada.