PREPARATION OF MESOPOROUS TITANIA-SILICA AEROGELS BY CO2 SUPERCRITICAL EXTRACTION

https://doi.org/10.22146/ijc.21686

Silvester Tursiloadi(1*), Dinie Mansur(2), Yeny Meliana(3), Ruslan Efendi(4)

(1) Research Center for Chemistry, Indonesian Institute of Sciences, Kawasan PUSPIPTEK, Serpong, Tangerang 15314, Indonesia
(2) Research Center for Chemistry, Indonesian Institute of Sciences, Kawasan PUSPIPTEK, Serpong, Tangerang 15314, Indonesia
(3) Research Center for Chemistry, Indonesian Institute of Sciences, Kawasan PUSPIPTEK, Serpong, Tangerang 15314, Indonesia
(4) Research Center for Chemistry, Indonesian Institute of Sciences, Kawasan PUSPIPTEK, Serpong, Tangerang 15314, Indonesia
(*) Corresponding Author

Abstract


Stable anatase is attractive because of its notable functions for photocatalysis and photon-electron transfer.  TiO2-nanoparticles dispersed SiO2 wet gels were prepared by hydrolysis of Ti(OC4H9n)4 and Si(OC2H5)4 in a 2-propanol solution with acid catalyst.  The solvent in the wet gels was supercritically extracted using CO2 at 60 oC and 22 Mpa in one-step.  Thermal evolution of the microstructure of the extracted gels (aerogels) was evaluated by XRD measurements, TEM and N2 adsorption measurements. The as-extracted aerogel with a large specific surface area, more than 365 m2g-1, contained anatase nanoparticles, about 5 nm in diameter.  The anatase phase was stable after calcinations at temperatures up to 1000 oC, and BET specific surface area, total pore volume and average pore diameter did not change significantly after calcinations at temperature up to 800 oC.


Keywords


Stable anatase; sol-gel; CO2 supercritical extraction

Full Text:

Full Text PDF


References

[1] Weaver, S. and Mills, G., 1997, J. Phys. Chem. B, 101, 3769

[2] Matsubara, H., Tanaka, M., Koyama, S., Hashimoto, K., and Fujishima, A., 1995, Chem. Lett., 1995, 767.

[3] Ohko, Y., Tryk, D.A., Hashimoto, K., and Fujishima, A., 1998, J Phys. Chem. B, 102 , 2699

[4] Sclafani, A., and Herrman, J.M., 1996, J. Mater. Res., 100, 13655

[5] Kormann, C., Bahnemann D.W., and Hoffmann, M.R., 1988, J. Phys. Chem., 92, 5196

[6] M. Anpo, T. Shima, S. Kodama, and Y. Kubokawa., 1987, J. Phys. Chem., 91, 4305

[7] Wang, C., Deng, Z.X., Zhang, G., Fan, S., and Li, Y., 2002, Powder Technol., 125, 39

[8] Cornell, R.M., Posner A.M., and Quirk, J.P., 1975, J. Colloid Interface Sci., 53, 6

[9] Mazdiyasni, K.S., Lynch C.T., and Smith, J.S., 1965, J. Am. Ceram. Soc., 48, 372

[10] Wang, C.C., and Ying, J.Y., 1999, Chem. Mater., 11, 3113

[11] Ovenstone, J., and Yanagizawa, K., 1999, Chem. Mater., 11, 2770

[12] Wang, T.Y.Q., Yin, L.X., Palchik, O., Hacohen, Y.R., Koltypin, Y., and Gedanken, A., 2001, Langmuir, 17, 4131.

[13] Mason (Ed.). 1990, Sonochemistry: The Uses of Ultrasound in Chemistry, Royal Society of Chemistry, Cambridge.

[14] Fujishima, A., and Honda, K., 1972, Nature 238, 37

[15] Phillips, R., 1983, Sources and Applications of Ultraviolet Radiation, p. 124, Academic Press, New York.

[16] Gedanken, A., Tang, X., Wang, Y., Perkas, N., Koltypin, Y., Landau, M.V., Vradman, L., and Herskowitz. M., 2001, Chem. Eur. J., 7, 4546.

[17] Srivastava, D.N., Perkas, N., Gedanken, A., and Felner. I., 2002, J. Phys. Chem. B 106, 1878.

[18] Srivastava, D.N., Chappel, S., Palchik, O., Zaban, A., and Gedanken, A., 2002, Langmuir 18, 4160.

[19] Suh, D.J., Park, T.J., Kim, J.H., and Kim, K.L., 1997, Chem. Mater., 9, 9, 1903

[20] Barret, E.P., Joyner L.G., and Halenda, P.H., 1951, J Am. Chem. Soc., 73, 373

[21] Imai, H., Morimoto, H., Tominaga, A., and Hirashima, H., 1997, J. Sol-gel Sci.and Tech., 10, 45

[22] Kasuga, T., Hiramatsu, M., Hoson, A., Sekino, T., and Niihara, K., 1999, Adv. Mater. 11, 1307.

[23] Kumar, K-N.P., Keizer, K., Burggraaf, A.J., Okubo, T. and Nagamoto, H., 1993, J. Mater. Chem. 3, 1151.

[24] Zhang, H. and Banfield, D.F., 1999, Am. Mineralogist, 84, 528

[25] Li, W., Ni, C., Lin, H., Huang, C.P. and Ismat S., 2004, J. Applied Physics, 96, 11, 663.

[26] Zhang, H. and Banfield, J. F., 2000, J. Phys. Chem. B, 104, 3481.



DOI: https://doi.org/10.22146/ijc.21686

Article Metrics

Abstract views : 2178 | views : 1289


Copyright (c) 2010 Indonesian Journal of Chemistry

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.

 

Indonesian Journal of Chemistry (ISSN 1411-9420 /e-ISSN 2460-1578) - Chemistry Department, Universitas Gadjah Mada, Indonesia.

Web Analytics View The Statistics of Indones. J. Chem.