Effect of Silica Fillers on Characterization of Cellulose-Acrylamide Hydrogels Matrices as Controlled Release Agents for Urea Fertilizers

https://doi.org/10.22146/ijc.21247

Deni Swantomo(1*), Rochmadi Rochmadi(2), Kris Tri Basuki(3), Rahman Sudiyo(4)

(1) Polytechnic Institute of Nuclear Technology, National Nuclear Energy Agency, Jl. Babarsari Kotak Pos 6101 YKBB Yogyakarta 55281
(2) Chemical Engineering Department, Universitas Gadjah Mada, Jl. Grafika No 2, Bulaksumur Yogyakarta 55281
(3) Polytechnic Institute of Nuclear Technology, National Nuclear Energy Agency, Jl. Babarsari Kotak Pos 6101 YKBB Yogyakarta 55281
(4) Chemical Engineering Department, Universitas Gadjah Mada, Jl. Grafika No 2, Bulaksumur Yogyakarta 55281
(*) Corresponding Author

Abstract


Controlled Release Urea Fertilizers-based hydrogels matrices was synthesized by graft copolymerization of acrylamide onto the rice straw cellulose backbones in the presence of silica fillers using simultaneous graft copolymerization by gamma irradiation as initiator. Evidence of the silica presence on grafted cellulose was obtained from FTIR. X-ray diffraction analysis showed that the crystalline was reduced through silica fillers added. The effect of silica content on grafting efficiency, gel fraction, Young modulus, swelling degree, and urea loading were examined. It was found that grafting efficiency and gel fraction decrease with increasing silica added inversely with Young modulus. Water swelling and loading urea fertilizers into hydrogels matrices were conducted and the results showed that swelling degree and urea fertilizers loading increased first and then decreased with increasing silica added. The effect of the silica fillers had implications in the mechanism of controlled release urea fertilizers that diffusion-controlled mechanism became dominant, which attributed to the decreasing of urea diffusion coefficient.

Keywords


silica fillers; hydrogels; gamma irradiation; controlled release urea fertilizers

Full Text:

Full Text Pdf


References

[1] Hekmat, A., Barati, A., Frahani, E.V., and Afraz, A., 2009, World Acad. Sci. Eng. Technol., 56, 96–100.

[2] Shavit, U., Reiss, M., and Shaviv, A., 2003, J. Controlled Release, 88 (1), 71–83.

[3] Bignotti, F., Lebon, F., and Peroni, I., 2007, Eur. Polym. J., 43 (5), 1996–2006.

[4] Córdoba, A.L., Deladino, L., and Martino, M., 2013, Carbohydr Polym., 95 (1), 315–323.

[5] Liu, T.Y., Chen, S.Y., Chen, S.C., and Liu, D.M., 2006, J. Nanosci. Nanotechnol., 6 (9-10), 2929–2935.

[6] Rao, K.S.V., Chung, I., and Ha, C.S., 2008, React. Funct. Polym., 68 (5), 943–953.

[7] Hosseinzadeh, H., 2011, Res. J. Pharm. Biol. Chem. Sci., 2 (2), 446–457.

[8] Hardinnawirda, K., and Aisha, S.R., 2012, J. Mech. Eng. Sci., 2, 181–186.

[9] Xiang, Y., and Chen, D., 2007, Eur. Polym. J., 43 (10), 4178–4187.

[10] Salgueiro, A.M., Daniel-da-Silva, A.L., Fateixa, S., and Trindade, T., 2013, Carbohydr. Polym., 91 (1), 100–109.

[11] Huang, W.J., Tsai, H.H., and Lee, W.F., 2010, Polym. Compos., 31 (10), 1712–1721.

[12] Acharya, H., and Srivastava, S.K., 2006, Macromol. Res., 14 (2), 132–139.

[13] Jamal, N.A., Anuar, H., and Razak, S.B.A., 2011, Can. J. Sci. Ind. Res., 2 (3), 95–101.

[14] Dubey, K.A., Chaudhari, C.V., Rao, R., Bhardwaj, Y.K., Goel, N.K., and Sabharwal, S., 2010, J. Appl. Polym. Sci., 118 (6), 3490–3498.

[15] Nada, M.A., El-Kady, M.Y., El-Sayed, S.Y., and Amine, F.M., 2009, BioResources, 4 (4), 1359–1371.

[16] Dubey, K.A., Bhardwaj, Y.K., Chaudhari, C.V., Kumar, V., Goel, N.K., and Sabharwal, S., 2009, eXPRESS Polym. Lett., 3 (8), 492–500.

[17] Pasbakhsh, P., Ismail, H., Fauzi, M.N.A., and Bakar, A.A., 2009, Polym. Test., 28 (5), 548–559.



DOI: https://doi.org/10.22146/ijc.21247

Article Metrics

Abstract views : 2183 | views : 1738


Copyright (c) 2014 Indonesian Journal of Chemistry

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial-NoDerivatives 4.0 International License.

 

Indonesian Journal of Chemistry (ISSN 1411-9420 /e-ISSN 2460-1578) - Chemistry Department, Universitas Gadjah Mada, Indonesia.

Web Analytics View The Statistics of Indones. J. Chem.